Do you have an problem with your Volvo Penta inboard ? We can help you with the EGC diagnostics manual just push the button BUY NOW, download the file and you can start right away.

This manual covers the following model(s):

4.3GXi-F(F), 4.3OSi-F(F)
5.0GXi-F(F), 5.0OSi-F(F)
5.7Gi-F(F), 5.7GXi-G(F)
5.7OSi-E(F), 5.7OSXi-E(F)
8.1Gi-G(F), 8.1GXi-F(F), 8.1OSi-C(F)

We only sell original manuals; the quality of the files is exceptionally good. When you print the file, the pictures are of good quality and very bright. WE DO NOT SELL ANY COPIED MANUALS, ONLY THE ORIGINAL!!!!

The manual has the following chapters:

General Information
Intake Manifold Vacuum Testing
Gasoline Requirements
Gasoline Containing Alcohol
Crankcase Oil
Off-Season Storage
Prepare a storage mixture
Change Motor Oil and Oil Filter
Change Sterndrive Lubricant
Drain Cooling System
Preparation for Boating After Storage
Engine Break-in
Submerged Engine
20-Hour Check
Belt Tension
Positive Closed-Type Ventilation System
Troubleshooting - System Isolation
Engine Troubleshooting Guides
Engine Will Not Crank
Engine Cranks, But Will Not Start
Hard Starting - Cold Engine
Hard Starting - Hot Engine
Engine Runs Rough
Engine Noises and Vibrations
Engine Overheats
Engine Dies Out
Engine Wont Reach Operating RPM
Defective Engine Lubricating System
Low Battery Voltage After Short Storage
Abbreviations


Visual / Physical Inspection
Basic Knowledge and Tools Required
Electrostatic Discharge Damage
Engine Wiring
Engine Control Module (ECM) Self-Diagnostics
Malfunction Indicator Lamp (MIL)
Intermittent Malfunction Indicator Lamp (MIL)
Reading Diagnostic Trouble Codes (DTCs)
Service Mode
Normal Mode
On-Board Diagnostic (OBD) System Check
DLC Scan Tools
Special Tool and Equipment

Volvo Penta Diagnostic Scan Tool

DTC 0016 - Never Crank Synced At Start
DTC 0107 - MAP Low Voltage
DTC 0108 - MAP High Pressure
DTC 0111 - IAT Higher Than Expected 1
DTC 0112 - IAT Low Voltage
DTC 0113 - IAT High Voltage
DTC 0116 - ECT Higher Than Expected 1
DTC 0117 - ECT Low Voltage
DTC 0118 - ECT High Voltage
DTC 0121 - TPS 1 Lower Than TPS 2
DTC 0122 - TPS 1 Signal Voltage Low (ETC)
DTC 0122 - TPS Signal Voltage Low (IAC)
DTC 0123 - TPS 1 Signal Voltage High (ETC)
DTC 0123 - TPS Signal Voltage High (IAC)
DTC 0127 - IAT Higher Than Expected 2
DTC 0129 - BP Low Pressure
DTC 0217 - ECT Higher Than Expected 2
DTC 0219 - Maximum Governor Speed Override
DTC 0221 - TPS 1 Higher Than TPS 2
DTC 0222 - TPS 2 Low Voltage
DTC 0223 - TPS 2 High Voltage
DTC 0261 - Injector Driver 1 Open
DTC 0264 - Injector Driver 2 Open
DTC 0265 - Injector Driver 2 Shorted
DTC 0267 - Injector Driver 3 Open
DTC 0268 - Injector Driver 3 Shorted
DTC 0270 - Injector Driver 4 Open
DTC 0271 - Injector Driver 4 Shorted
DTC 0273 - Injector Driver 5 Open
DTC 0274 - Injector Driver 5 Shorted
DTC 0276 - Injector Driver 6 Open
DTC 0277 - Injector Driver 6 Shorted
DTC 0279 - Injector Driver 7 Open
DTC 0280 - Injector Driver 7 Shorted
DTC 0282 - Injector Driver 8 Open
DTC 0283 - Injector Driver 8 Shorted
DTC 0326 - Knock 1 Excessive Signal
DTC 0327 - Knock Sensor 1 Open
DTC 0331 - Knock 2 Excessive Signal
DTC 0332 - Knock Sensor 2 Open
DTC 0336 - Crank Sync Noise
DTC 0337 - Crankshaft Sensor Loss
DTC 0341 - Camshaft Sensor Noise
DTC 0342 - Camshaft Sensor Loss
DTC 0508 - IAC Ground Short
DTC 0509 - IAC Coil Open/Short
DTC 0522 - Oil Pressure Sender Low Voltage
DTC 0523 - Oil Pressure Sender High Voltage
DTC 0524 - Low Oil Pressure
DTC 0562 - System Voltage Low
DTC 0563 - System Voltage High
DTC 0601 - Flash Checksum Invalid
DTC 0604 - RAM Failure
DTC 0606 - COP Failure
DTC 0627 - Fuel Pump Relay Coil Open
DTC 0628 - Fuel Pump Relay Control Ground Short
DTC 0629 - Fuel Pump Relay Coil Short to Power
DTC 0642 - V REF #1 Voltage Low (ETC)
DTC 0642 - V REF Voltage Low (IAC)
DTC 0642 - V REF Voltage Low (IAC)
DTC 0643 - V REF #1 Voltage High (ETC)
DTC 0643 - V REF Voltage High (IAC)
DTC 0652 - V REF #2 Voltage Low
DTC 0653 - V REF #2 Voltage High
DTC 0685 - Ignition Relay Coil Open
DTC 0686 - Ignition Relay Control Ground Short
DTC 0687 - Ignition Relay Coil Short to Power
DTC 1111 - Fuel Rev Limit
DTC 1112 - Spark Rev Limit
DTC 1121 - TCP 1/2 Simultaneous Voltages Out-of-Range
DTC 1122 - TCP 1 and TCP 2 Do Not Match or IVS
DTC 1511 - Trim Sender Voltage High (2-Wire)
DTC 1511 - Trim Sender Voltage High (3-Wire)
DTC 1611 - 5V 1/2 Simultaneous Out-of-Range
DTC 1612 - RTI 1 Loss
DTC 1613 - RTI 2 Loss
DTC 1614 - RTI 3 Loss
DTC 1615 - A/D Loss
DTC 1616 - Invalid Interrupt
DTC 1628 - CAN Address Conflict Failure
DTC 1631 - Water Temperature Gauge Open/Short to Ground
DTC 1631 - Water Temperature Gauge Open/Short to Ground
DTC 1632 - Water Temperature Gauge Short to Power
DTC 1633 - Oil Pressure Gauge Open / Short to Ground
DTC 1634 - Oil Pressure Gauge Short to Power
DTC 1635 - Trim Position Gauge Open / Short to Ground
DTC 1636 - Trim Position Gauge Short to Power
DTC 1641 - Buzzer Control Ground Short
DTC 1642 - Buzzer Open
DTC 1643 - Buzzer Control Short to Power
DTC 2111 - Throttle Unable To Close
DTC 2112 - Throttle Unable To Open
DTC 2115 - TCP 1 Higher Than IVS limit
DTC 2116 - TCP 2 Higher Than IVS Limit
DTC 2120 - TCP 1 Invalid Voltage, TCP 2 Disagrees with IVS
DTC 2121 - TCP 1 Lower Than TCP 2
DTC 2122 - TCP 1 High Voltage
DTC 2123 - TCP 1 Low Voltage
DTC 2125 - TCP 2 Invalid Voltage, TCP 1 Disagrees with IVS
DTC 2126 - TCP 1 Higher Than TCP 2
DTC 2127 - TCP 2 Low Voltage
DTC 2128 - TCP 2 High Voltage
DTC 2130 - IVS Stuck At-Idle TCP 1/2 Match
DTC 2131 - IVS Stuck Off-Idle
DTC 2135 - TPS 1/2 Simultaneous Voltages Out-of-Range
DTC 2139 - TCP 1 Lower Than IVS limit
DTC 2140 - TCP 2 Lower Than IVS Limit
DTC 2229 - BP High Pressure
DTC 2428 - EGT Temperature High
DTC 2618 - Tachometer Output Ground Short
DTC 2619 - Tachometer Output Short to Power

ECM Limits

Vodia Index by Number



If you have a request, dont hesitate to ask us.

Language: English
Format: PDF
Pages: 469